We no longer sell NOS Kits!

These were the instructions to fitting our NOS Kit, they have been left only as I can't see how to remove from guides.

What you'll need
Screw driver
Drill with 12.5mm bit.

Ok here’s how to fit your new mini nitro kit;
Get your bike on a bench or table (not the dinner table or the Mrs will batter you)

You need to drill a 12.5mm hole in the filter box/air intake. ~The idea is that the gas goes straight into the intake, increasing the amount of oxygen used when the fuel ignites!

Pull the yellow hose off the bulk-head fitting by pulling back the black plastic holder & pulling out the hose at the same time.

Then fit the bulk-head fitting behind the air/filter cover & screw the nut back on.

Make sure you clear away all the debris from the drilling otherwise this will get sucked into the engine! & that ain’t good!

**IMPORTANT** This bulk head fitting must be secure & tight or it might tear itself through the cover. If you want to make sure this doesn’t happen then strengthen it with a large washer or something like that.

Push the tube firmly into the black fitting & pull to test it’s in properly.

Use the cable-ties to run the hose along the frame – make sure it doesn’t touch anything that gets hot or restrict movement of handlebars.

Attach the ultraflate to the handlebars with cable ties. If you want to make it more secure use jubilee clips. Oh & don’t forget to think about placing it so it’s easy to put chargers in & out & pull trigger when in motion.

To fire it up & have some fun!!
Push the red safety clip to on position (upwards). Put a charger into the holder (unscrew & place in bottom part of ultraflate) screw back together firmly but don’t over tighten.

Start your engine & let her rip, gently squeeze the trigger! Make sure the engine is under load when you fire it up otherwise it over revs it.

Good luck & be careful!

Always wear safety equipment/clothing

This is your conscience, body & most of all ya bike!! Remember when you pull the trigger it goes & I mean really goes!  So use with respect until you are equipped to keep it on the road, or skidding on ya ass after flipping out you’re gonna be sweetie!!

Any damage to equipment, yourself &/ any other people, objects, structures, other vehicles, fence posts etc etc is your responsibility.

If you are big enough to need extreme sport fun, then ya big enough to do it safely & in the right place!!